The study showed that the system improved participants’ blood glucose control throughout the day and overnight. The latter is a common but serious challenge for children and adults with type 1 diabetes, since blood glucose can drop to dangerously low levels when a person is asleep. The research was published in the New England Journal of Medicine.
The artificial pancreas, also known as closed-loop control, is an all-in-one diabetes management system that tracks blood glucose levels using a continuous glucose monitor (CGM) and automatically delivers the hormone insulin when needed using an insulin pump. The system replaces reliance on testing by fingerstick or CGM with separate delivery of insulin by multiple daily injections or a pump.
This six-month study was the third phase in a series of trials. It was conducted with participants living their usual day-to-day lives, so the researchers could best understand how the system worked in typical daily routines.
“Testing the safety and effectiveness of new technologies in real-world settings is critical to prove the usability of these systems by people with diabetes to achieve a better daily control of their blood glucose levels,” said Guillermo Arreaza-Rubín, M.D., director of NIDDK’s Diabetes Technology Program and project scientist for the study. “Earlier technologies have made the management of type 1 diabetes easier, and this research shows that this artificial pancreas system has the potential to improve the health of people living with type 1 diabetes, while also potentially lifting much of the burden of care from those with the disease and their caregivers.”
This iDCL protocol enrolled 168 participants age 14 or older with type 1 diabetes. They were randomly assigned to use either the artificial pancreas system called Control-IQ or sensor-augmented pump (SAP) therapy with a CGM and insulin pump that did not automatically adjust insulin throughout the day. Participants had contact with study staff every two to four weeks to download and review device data. No remote monitoring of the systems was done, so that the study would reflect real-world use.
The researchers found that users of the artificial pancreas system significantly increased the amount of time with their blood glucose levels in the target range of 70 to 180 mg/dL by an average of 2.6 hours per day since beginning the trial, while the time in range in the SAP group remained unchanged over six months. Artificial pancreas users also showed improvements in time spent with high and low blood glucose, hemoglobin A1c, and other measurements related to diabetes control compared to the SAP group. High adherence to device use in both groups and 100% percent participant retention were important strengths of the study. During the study, no severe hypoglycemia events occurred in either group. Diabetic ketoacidosis occurred in one participant in the artificial pancreas group due to a problem with equipment that delivers insulin from the pump.
The Control-IQ technology was derived from a system originally developed at the University of Virginia, Charlottesville, (UVA) by a team led by Boris Kovatchev, Ph.D., director of the UVA Center for Diabetes Technology with funding support from NIDDK. In this system, the insulin pump is programmed with advanced control algorithms based on a mathematical model that uses the person’s glucose monitoring information to automatically adjust the insulin dose. Tandem Diabetes Care has submitted the results to the U.S. Food and Drug Administration for approval to market the Control-IQ system.
“This artificial pancreas system has several unique features that improve glucose control beyond what is achievable using traditional methods,” said Kovatchev. “In particular, there is a special safety module dedicated to prevention of hypoglycemia, and there is gradually intensified control overnight to achieve near-normal blood sugar levels every morning.”
Kovatchev was co-lead author of the study with colleagues Sue A. Brown, M.D., of UVA and Roy Beck, M.D., Ph.D., from the Jaeb Center for Health Research, Tampa, Florida, which was the coordinating center for the study.
“Artificial pancreas technology has tremendous potential to improve the day-to-day lives of people with type 1 diabetes,” said NIDDK director Griffin P. Rodgers, M.D. “By making management of type 1 diabetes easier and more precise, this technology could reduce the daily burden of this disease, while also potentially reducing diabetes complications including eye, nerve, and kidney diseases.”
The iDCL Study is one of four major research efforts funded by NIDDK through the Special Statutory Funding Program for Type 1 Diabetes to test and refine advanced artificial pancreas systems. The studies, with additional results forthcoming, are looking at factors including safety, efficacy, user-friendliness, physical and emotional health of participants, and cost.
The study was funded through NIDDK grant UC4DK108483. Tandem Diabetes Care provided the experimental closed-loop systems, supplies, and technical expertise with device issues. The University of Virginia Strategic Investment Fund Project #88 provided institutional and regulatory support.